AOPA Turbine Pilot Magazine - February 2015 - 20

SAFETY PILOT

High flight

BY BRUCE LANDSBERG

Know your flight physiology

BRUCE LANDSBERG

serves in an
advisory
capacity for the
AOPA Foundation and Air Safety
Institute. He retired
from the association in 2014.

WITH APOLOGIES to Flight Officer John Gillespie Magee,
forget the surly bonds and all that soaring and wheeling
in the sunlit castles of the flight levels. It's not a benign
environment, as two accidents in the waning months of
2014 proved. A turbocharged Cirrus SR22 and a TBM
900 flown by experienced pilots went down within a
week of each other. Both aircraft were intercepted, the
pilots unresponsive, and flew on until fuel exhaustion.
Currently there are only preliminary accident reports,
and probable cause may never be determined-neither
aircraft was recovered after crashing into the ocean.
Hypoxia almost certainly was the cause, but we may
never know why.
Accidents involving pressurized aircraft and total
pilot incapacitation are rare; the last high-profile tragedy involved golfer Payne Stewart, whose chartered
Lear 35 went down after its pressurization system failed.
Partial incapacitation and the resulting crashes are more
common but nearly impossible to document, since there
are no residual markers. Good pilots make inexplicable
decisions and mistakes with tragic results.
The FARs require that for personal flight (Part 91)
pilots use oxygen when flying at or above 12,500 feet
msl for more than 30 minutes. Apparently we're better
physical specimens and less susceptible than Part 135
pilots, who must comply with these same rules beginning at 10,000 feet.
FAR 61.31(g) requires training when operating above
FL250. For the hypoxia portion, a quick and inexpensive way involves changing the gas mixture fed to the
pilot. Don a mask with degraded elixir and soon you're
hypoxic. Another approach is the altitude chamber,
which introduces hypoxia and pressurization challenges. Senior Editor Dave Hirschman and I flew to the
National Aerospace Training and Research (NASTAR)
Center in Philadelphia to take its one-day course.
NASTAR's ground school takes about two hours.
The chamber resembles a small boxcar and is built to
endure massive differentials. Gigantic pipes pressurize and empty the box while complex controls manage
the atmospherics without destroying the subjects (us).
Rapid decompression was popularized in the 1960s
movie Goldfinger when the villain was sucked out the
window of a high-flying jet. Keep your seat belt fastened.
Our rapid depressurization demo was relatively gentle (8,000-foot cabin to 25,000 feet). Quicker than you
can say "Aw, shucks," the air literally rushes out of the

20 | AOPA PILOT February 2015

body, the cabin fogs up immediately, and it gets really
cold. The chamber's airspeed is not 300-plus knots and
the outside air temperature isn't minus 50 degrees, so
the airlines' warning that "the masks will drop from
the ceiling if there's a change in cabin pressure" doesn't
begin to do reality justice.
But rapid decompression isn't how hypoxia usually
happens-and unpressurized aircraft can't depressurize.
Pilots slowly lose their abilities and, what's worse, they
don't care! After a few test runs to clear our ears and
make sure we had no sinus pain, we climbed to 25,000
feet and removed our masks. The time of useful consciousness is less than five minutes. Move into the high
flight levels and it's measured in seconds. That's why
jets are equipped with quick-don masks.
Unlike the unsuspecting real world, we knew what
was coming. In about three minutes everyone in our
group decided they'd had enough. My symptoms were
light-headedness, bluing around the fingernails, and
visual degradation, but your reaction may be different.
Oxygen saturation drops from 100-percent oxygen to
less than 80 percent in just minutes at that altitude. A
pulse oximeter can be purchased almost anywhere for
under $50 and is an essential piece of cross-country
gear. It clips on a finger and shows oxygen saturation.
Down to 90 percent, all is good. Slip to the high 80s
and it's time to supplement. Mid-80s means oxygen
is needed. Long flights above 10,000 feet are oxygendepriving. Some high-country folks will do better, but
eventually we are all susceptible.
The chamber was then blacked out and run up to
18,000 feet. In dim light we were asked to discern various colors; not so good. Oxygenated, the colors popped
right out. We need it at night above 5,000 feet.
In real flight, hypoxia creeps up slowly, and stupidity strikes with stealth. Feeling a little dizzy, tired, or just
really happy to be flying? Get some good air. Spending
the day at 9,000 feet, as many us of do on long flights,
takes its toll. Deep breathing helps a little but unless
you're prepared to do that for extended periods, which
is tiring itself, just go for oxygen-or fly lower.
Flying pressurized? Take the chamber ride. There
are multiple places around the country to go. Knowing
your flight physiology is part of becoming a wellrounded, safe pilot.
AOPA
WEB www.airsafetyinstitute.org

http://www.airsafetyinstitute.org

AOPA Turbine Pilot Magazine - February 2015

Table of Contents for the Digital Edition of AOPA Turbine Pilot Magazine - February 2015